王 俊,申立中,文奕鈞,薛 爽,趙 杰
小型農用柴油機高原增壓匹配與適應性研究
王 俊1,申立中2,文奕鈞3,薛 爽3,趙 杰3
(1. 西南林業大學機械與交通學院,昆明 650224;2. 昆明理工大學云南省內燃機重點實驗室,昆明 650500;3. 昆明云內動力股份有限公司,昆明 650200)
中國高原地區運行的農業機械數量眾多,為保證在這些地區使用的農業機械具有良好的高原適應性,以一款小型農用柴油機為研究對象,在海拔2 000 m的地區,根據設計開發目標,通過理論計算選取了合適的壓氣機和渦輪,并進行了配機試驗?;谠囼灁祿?,采用GT-Power軟件建立了該小型農用增壓柴油機的仿真模型,模擬研究了該柴油機關鍵性能參數隨海拔(0、2 000、4 000 m)變化的規律。研究結果表明:選配的渦輪增壓器使得該小型農用柴油機達到了高原地區2 000 m的性能開發目標;在3個海拔下,柴油機與壓氣機的聯合運行線均運行在效率相對較高的區域,并且低速時具有較大的喘振裕度,在高速時離阻塞線也有一定的距離;與平原地區相比,在海拔2 000和4 000 m時,小型農用柴油機的最大轉矩分別降低了2.59%和7.19%,與已有的文獻結論相比,最大轉矩的降幅減??;在高原地區有針對性地進行增壓匹配,能夠保證柴油機良好的高原運行性能,并有利于提高柴油機的高原適應性。
柴油機;高原;增壓匹配;不同海拔;適應性
中國高原分布廣闊,海拔1 000 m以上的高原面積約占中國總面積的58%;2 000 m以上的高原占33%[1-2]。截止2018年,據不完全統計,運行在高原地區的農業機械總量達到1 526萬臺之多[3-4]。隨著國家對農機購置補貼力度的加大,在高原地區運行的農業機械數量將進一步攀升。柴油機具有高轉矩、低油耗、高熱效率等優點[5],95%以上的農業機械采用柴油機作為動力單元[6]。
在高原地區,空氣稀薄,進入氣缸的空氣量減少,燃燒惡化,導致柴油機的綜合運行性能降低[7-9]。自然吸氣柴油機的高原環境適應性明顯低于增壓柴油機[10]。在高原環境下,渦輪增壓器具有一定的自補償能力[11-12],能夠在一定程度上減小高原低氣壓環境對柴油機性能的影響[13]。增壓匹配為恢復柴油機高原性能提供了良好的技術方案[14-15]。李書奇等[16]的研究表明:排氣旁通渦輪增壓器具有較高的轉矩儲備系數,可用于高原環境適應性柴油機動力的改進。靳嶸等[17]的研究顯示:采用可變噴嘴渦輪增壓器(VNT),柴油機高海拔性能下降問題得到改善,在海拔4 000 m時,柴油機的最大轉矩轉速恢復到平原條件下的1 300 r/min,轉矩降幅低于5%。Carlucci等[18]的仿真表明:與單級渦輪增壓相比,匹配2個渦輪增壓系統的二沖程柴油機在不同海拔高度(0、3 050、5 180、10 670 m)均有更高的輸出功率。李華雷等[19]的研究表明:柴油機采用兩級可調增壓系統可以實現海拔3 000和4 500 m的功率恢復目標。謝海江等[20]進行了類似的研究,采用旁通閥的變海拔控制策略,可以在海拔3 000 m下使柴油機的增壓壓力恢復到原機平原水平,但在高海拔高轉速工況下可能發生增壓器超速現象。韓愷等[21]提出了采用可調復合增壓系統恢復高原柴油機功率的方案,模擬結果顯示:采用所提出的復合增壓方案能夠在海拔3 000 m的高度使柴油機的標定功率恢復至平原的89.7%,最大轉矩下降3.7%。Xia等[22]采用渦輪-機械復合增壓系統對某6缸柴油機進行了高原功率恢復研究,模擬結果表明:在4 500 m的海拔高度,采用該復合增壓系統的柴油機的額定功率能夠恢復至原機單級渦輪增壓柴油機平原功率的80%;在1 500 r/min以下,轉矩恢復至原機85%的平原水平。商海昆等[23]采用雙增壓器與柴油機進行了高原匹配研究,結果表明:所提出的雙增壓器的方案有效地解決了原機低速喘振、高速超速問題;在海拔4 500 m時,最大轉矩比原機下降了6.8%,最大功率比原機下降了24.7%。
從上述文獻可以看出,柴油機的高原性能恢復研究多數采用高增壓技術,如可變幾何截面增壓技術、兩級渦輪增壓技術,并沒有在高原地區進行有針對性地的增壓匹配,以提高柴油機的高原適應性。然而,目前,增壓匹配多數在平原地區進行配機試驗,以平原地區柴油機的各項性能參數為主選配渦輪增壓器。當柴油機運行在高原地區時,由于壓氣機的壓比和折合流量均同時增大[24],使得柴油機與壓氣機的聯合運行線偏離壓氣機的高效率區域,難以發揮匹配渦輪增壓器的最佳性能。采用增壓技術的主要目的是提高柴油機的進氣流量。在高原環境下,大氣壓力降低,進氣流量減少,良好的增壓匹配對恢復柴油機的運行性能顯得尤為重要。
與機動車相比,以柴油機為動力單元的農業機械流通性較差,多數在固定的區域進行作業,因此有必要針對運行在高原地區的農用柴油機進行增壓匹配,使其具有更好的高原適應性。中國山地面積占全國土地面積的60%左右,包括了從海拔10 m以下的長江三角洲平原到海拔4 000 m左右的青藏高原[25]。為此,選取中間海拔,在2 000 m的高原地區,以某小型農用柴油機為研究對象,首先,根據設計開發目標,通過理論計算選取了合適的壓氣機和渦輪,基于柴油機與壓氣機的聯合運行線,展現了高原地區增壓匹配的必要性;其次,在2 000 m的高原地區,進行了渦輪增壓器的配機試驗;最后,根據試驗數據,采用GT-Power軟件建立了該小型農用增壓柴油機的仿真模型,模擬研究了該柴油機關鍵性能參數隨海拔變化的規律,分析了該柴油機的高原適應性。該研究為運行在高原地區的非道路用柴油機的增壓匹配和性能提升提供了一定的參考依據。
在眾多的增壓技術方案中,排氣旁通渦輪增壓器具有結構簡單、成本低以及在高溫環境下工作良好等優點[26-27],其適用于控制成本和低速大負荷運行特點的農業機械。因此,選用排氣旁通渦輪增壓器與小型農用柴油機進行匹配。
該小型農用柴油機的基本設計參數如表1所示,并要求在海拔2 000 m的地區,低速轉矩不得低于120 N·m,最大轉矩達到180 N·m,轉矩儲備系數(定義為外特性工況的最大轉矩與標定功率點的轉矩之比[11])不低于125%。
表1 發動機基本設計參數
式中0為試驗時測得的大氣壓力,MPa;0為試驗時測得的大氣溫度,K。
進入氣缸的空氣體積流量V(m3/s)為
由理想氣體狀態方程得到壓氣機出口壓力2(MPa)
式中為氣體常數,287 J/(kg·K);2為壓氣機出口溫度,K。
1)有排氣旁通時
2)無排氣旁通時
式中3為渦輪進口溫度,K;3為渦輪進口壓力,MPa。
渦輪增壓器功率平衡計算公式為
根據經驗和相似機型選取在海拔0 m(平原地區)、2 000 m以及4 000 m下3個匹配點的相關計算參數(如表2所示),利用上述計算公式,分別計算出3個匹配點的參數,如表3所示。
表2 小型農用柴油機分別在海拔0、2 000以及4 000 m時3個匹配點選取的相關計算參數
注:在不同海拔下,轉速為2 600 r·min-1時的渦輪排氣旁通量均設為15%。
Note: At different altitudes, exhaust bypass of turbine are all set 15% at engine speed 2 600 r·min-1.
表3 不同海拔下3個典型工況的匹配計算結果
表4 增壓器基本結構參數
根據表3的計算結果和增壓器廠商提供的渦輪增壓器,以海拔高度2 000 m為主,兼顧平原地區(0 m)與更高海拔4 000 m的性能,選定滿足計算要求的增壓器,其結構參數如表4所示,將計算的匹配點置于壓氣機MAP上,如圖1所示。從圖中可以看出,在海拔2 000 m時,柴油機與壓氣機聯合運行線穿過壓氣機的高效率區域,在海拔0 m和4 000 m時的聯合運行線也運行在效率相對較高的區域,并且在2 000和4 000 m的高原地區,柴油機與壓氣機的聯合運行線離喘振線和阻塞線均有較大裕量。如果按照平原地區匹配增壓器,使得平原地區的聯合運行線穿過壓氣機的高效率區域,可能導致高海拔地區增壓器出現超速現象,并且聯合運行線也運行在效率相對較低的區域,如圖2所示。由此可見,在海拔2 000 m的地區匹配增壓器,可以兼顧平原地區壓氣機的性能以及防止更高海拔下增壓器超速現象的發生。
注:100 000 r·min-1表示壓氣機轉速,余同;60%表示壓氣機效率,余同。
圖2 平原地區匹配增壓器時不同海拔下的柴油機與壓氣機匹配示意圖
在選定渦輪增壓器之后,在海拔高度約為2 000 m的地點進行了配機試驗。試驗用到的主要設備有杭州奕科機電技術有限公司的WE31N水渦流測功機、FCMA油耗儀、EIM609測控系統、K型熱電偶、PTX1400壓力傳送器等。
試驗結果如圖3所示,由圖3可見,在海拔2 000 m的地區,匹配渦輪增壓器之后該小型農用柴油機在1 000 r/min時達到了120.1 N·m;最大轉矩為180.2 N·m,對應的轉速為1 600 r/min;外特性工況下的最低油耗為229.2 g/(kW·h),對應的轉速為1 800 r/min;額定功率達到了37.4 kW,對應的轉速為2 600 r/min;最高渦前溫度為627.5 ℃,對應的轉速為1 600 r/min;轉矩儲備系數達到了131%。該小型農用增壓柴油機的各項性能指標達到了高原地區2 000 m的性能開發要求。
基于試驗條件的限制,采用GT-Power軟件,根據高原地區2 000 m下的試驗數據建立了該小型農用增壓柴油機的仿真模型。該仿真模型包括環境模塊、進排氣管道模塊、噴油器模型、燃燒模型、傳熱模型、摩擦模型以及壓氣機和渦輪模塊等,其中,壓氣機和渦輪的MAP數據以增壓器廠商提供的數據為輸入。在仿真過程中假設工質為理性氣體,氣體的流動過程為準穩態過程,缸內的工質混合均勻且燃燒完全。
對于機械式排氣旁通渦輪增壓器,在實際中通過調節彈簧預緊力達到預設的增壓壓力;而在仿真模型中,通過調節旁通閥門直徑大小匹配試驗測得的增壓壓力,且在不同海拔的模擬中,在柴油機的中高轉速段,通過調節旁通閥門直徑大小以防止增壓器出現超速現象。在建立模型時,采用PID控制器控制每循環噴油量以達到試驗數據外特性工況下的功率;在模擬海拔0和4 000 m的性能時,給定在2 000 m時獲得的噴油量進行仿真計算。
圖3 海拔2 000 m時小型農用柴油機的外特性曲線
在海拔為2 000 m時,該小型農用柴油機外特性工況下的試驗數據與仿真結果對比如圖4所示。由圖4可知,轉矩的試驗與仿真曲線幾乎重合,中高轉速下增壓壓力的試驗值與仿真值也幾乎相等,這是由于在仿真中分別采用PID控制器控制每循環噴油量匹配功率以及調節放氣閥門直徑大小匹配增壓壓力的結果,在增壓壓力的低轉速范圍內,試驗值與仿真值的最大偏差出現在1 000 r/min為5.3%。有效燃油消耗率和渦前溫度的試驗數據與仿真值變化趨勢基本一致,吻合較好,這表明建立的仿真模型具有良好的準確性,可以用于不同海拔下的仿真計算。
圖5a為等油量下,外特性工況的轉矩隨海拔的變化。由圖可見,在相同轉速下,轉矩隨著海拔的升高而降低;在低速范圍內,轉矩隨著海拔的升高下降幅度增大,隨著轉速的升高,轉矩的降幅逐漸減小;最大轉矩對應的轉速呈現逐漸向高轉速移動的趨勢,這與文獻[29]的研究結論一致。在平原地區,該小型農用柴油機的最大轉矩為185.0 N·m,對應轉速為1 600 r/min;在海拔為2 000 m時,最大轉矩為180.2 N·m,對應轉速為1 600 r/min;在海拔為4 000 m時,最大轉矩為171.7 N·m,對應轉速為1 800 r/min。與平原地區相比,在海拔為2 000和4 000 m時,最大轉矩分別下降2.59%和7.19%。與文獻[30]和[31]的結論相比,在海拔為2 000和4 000 m時,最大轉矩的降幅減小,這說明在高原地區進行增壓匹配,有利于提高柴油機的高原適應性。
圖4 海拔2 000 m時小型農用柴油機外特性工況下的試驗值與仿真值對比
海拔對有效燃油消耗率的影響如圖5b所示。在相同轉速下,有效燃油消耗率隨著海拔的升高而升高;隨著海拔的升高,在低速時,小型農用柴油機的有效燃油消耗率升高幅度較大,隨著轉速的升高,油耗的升幅逐漸降低。與平原地區相比,在海拔2 000和4 000 m時,有效燃油消耗率平均升高了1.95%和5.21%。隨著海拔的升高,大氣壓力降低,空氣密度減小使得吸入氣缸內的進氣流量降低,燃燒所需的空氣量減少,燃燒惡化,輸出功率降低,熱效率下降;另外,隨著柴油機轉速的升高,渦輪做功能力增強,進氣不足的現象逐漸改善,因而呈現上述變化趨勢。
圖5c為海拔對增壓壓力的影響。從圖中可以看出,在相同轉速下,增壓壓力隨著海拔的升高而降低。渦輪增壓器雖然在高原地區具有一定的自補償能力,但仍不足以抵消大氣環境壓力的降低[32],因而增壓壓力隨海拔的升高而降低。當轉速高于1 600 r/min時,在海拔0 m時,增壓壓力隨轉速的升高變化趨于平緩;而在2 000和4 000 m海拔下,增壓壓力仍隨轉速的升高而略有增大。這主要是因為此時排氣旁通閥已經部分開啟,隨著海拔的升高,在不發生增壓器超速的前提下,適當減小排氣旁通閥的開度有利于恢復一部分進氣流量,提高柴油機的高原適應性。
圖5 海拔對小型農用柴油機關鍵性能參數的影響
海拔對渦前溫度的影響如圖5d所示。在相同轉速下,渦前溫度隨著海拔的升高而升高。在轉速低于1 600 r/min時,渦前溫度隨轉速的升高而升高;而轉速高于1 600 r/min時,渦前溫度隨轉速的升高而逐漸降低。這主要是因為渦前溫度與缸內的燃燒過程有關。隨著海拔升高,進入缸內的進氣流量降低,壓縮終點的壓力降低,加之缸內的含氧量也隨之減少,使得燃燒過程推遲,后燃現象加重,渦前溫度隨之升高。在轉速較低時,進氣流量較低,而每循環的噴油量逐漸加大,混合氣形成質量較差,滯燃期延長,燃料在急燃期和緩燃期階段無法完全燃燒,后燃現象加劇,在1 600 r/min時,為了獲得最大轉矩,噴油量較大,此時混合氣質量進一步惡化,從而使得渦前溫度達到峰值;隨著轉速升高,進氣流量逐漸增大,缸內混合氣的質量逐步改善,滯燃期縮短,燃燒始點提前,后燃現象減小,渦前溫度相應降低。從圖中還可以看出,在不同海拔下的最高渦前溫度低于680 ℃,滿足設計的約束條件。
圖6為小型農用柴油機與壓氣機聯合運行線隨海拔的變化。由圖可見,在相同的轉速小,壓氣機壓比和折合流量均隨著海拔的升高而增大;以高原2 000 m為主的增壓匹配,聯合運行線穿過壓氣機的高效率區域,同時,海拔0和4 000 m的聯合運行線也運行在相對較高的效率區域;在3個海拔下,低速時均具有較大的喘振裕度,在高速時離阻塞線也都有一定的距離。
圖6 小型農用柴油機與壓氣機聯合運行線隨海拔的變化
1)在海拔2 000 m的地區,通過理論計算選配的渦輪增壓器,經臺架配機試驗表明,該小型農用增壓柴油機達到了高原地區2 000 m的性能開發目標。1 000 r/min的轉矩達到了120.1 N·m;最大轉矩達到了180.2 N·m,對應的轉速為1 600 r/min;額定功率達到了37.4 kW,對應的轉速為2 600 r/min;轉矩儲備系數達到了131%。
2)與已有的文獻結論相比,在海拔為2 000和4 000 m時,最大轉矩的降幅減小;與平原地區相比,在海拔為2 000和4 000 m時,最大轉矩降幅分別為2.59%和7.19%。在高原地區有針對性地進行增壓匹配,有利于提高柴油機的高原適應性。
3)選配的渦輪增壓器可以有效避免運行在4 000 m海拔地區時壓氣機的低速喘振與高速超速現象,并且在平原地區和海拔4 000 m的高原,柴油機與壓氣機的聯合運行線均運行在效率相對較高的區域。
[1] Zhang H, Zhuge W, Zhang Y, et al. Study of the control strategy of the plateau self-adapted turbocharging system for diesel engine[C]//SAE International Powertrains, Fuels & Lubricants Congress, 2008.
[2] Yu L, Ge Y, Tan J, et al. Experimental investigation of the impact of biodiesel on the combustion and emission characteristics of a heavy duty diesel engine at various altitudes[J]. Fuel, 2014, 115: 220-226.
[3] 蘇春華. 新時期西藏農機化發展建議[J]. 農機科技推廣, 2017(10): 31-32.
[4] 魏學慶. 談如何搞好青海農機維修工作[J]. 農機使用與維修, 2013(10): 4-4.
[5] 王俊, 申立中, 王貴勇, 等. 基于參變量掃值的非道路用柴油機增壓匹配[J]. 農業工程學報, 2014, 30(17): 63-70. Wang Jun, Shen Lizhong, Wang Guiyong, et al. Turbocharger matching for non-road diesel engine base on parametric sweeping[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE) 2014, 30(17): 63-70. (in Chinese with English abstract)
[6] 譚丕強, 王德源, 樓狄明, 等. 農業機械污染排放控制技術的現狀與展望[J]. 農業工程學報, 2018, 34(7): 1-14. Tan Piqiang, Wang Deyuan, Lou Diming, et al. Progress of control technologies on exhaust emissions for agricultural machinery[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2018, 34(7): 1-14. (in Chinese with English abstract)
[7] Liu S, Shen L, Bi Y, et al. Effects of altitude and fuel oxygen content on the performance of a high pressure common rail diesel engine[J]. Fuel, 2014, 118: 243-249.
[8] 申立中, 楊永忠, 雷基林, 等. 不同海拔下增壓中冷柴油機性能和排放的研究[J]. 內燃機學報, 2006, 24(3): 250-255. Shen Lizhong, Yang Yongzhong, Lei Jilin, et al. Study of performance and emissions of a turbocharged inter-cooling diesel engine at different altitudes[J]. Transactions of CSICE, 2006, 24(3): 250-255. (in Chinese with English abstract)
[9] Wang X, Yin H, Ge Y, et al. On-vehicle emission measurement of a light-duty diesel van at various speeds at high altitude[J]. Atmospheric Environment, 2013, 81: 263-269.
[10] 董素榮, 劉鵬宇, 牟永輝, 等. 車用柴油機高原環境適應性評價研究[J]. 汽車技術, 2016 (2): 38-42. Dong Surong, Liu Pengyu, Mou Yonghui, et al. Research on evaluation of plateau environmental adaptability of automobile diesel engine[J]. Automobile Technology, 2016 (2): 38-42. (in Chinese with English abstract)
[11] 周龍保. 內燃機學.第3版[M]. 北京: 機械工業出版社, 2011.
[12] 申立中, 楊永忠, 雷基林, 等. 不同海拔地區下增壓中冷柴油機的性能研究[J]. 汽車工程, 2005, 27(6): 674-677. Shen Lizhong, Yang Yongzhong, Lei Jilin, et al. A study on the performance of turbocharged and intercooled diesel engine working in the different altitude regions[J]. Automotive Engineering, 2005, 27(6): 674-677. (in Chinese with English abstract)
[13] Chiong M S, Rajoo S, Martinez-Botas R F, et al. Engine turbocharger performance prediction: One-dimensional modeling of a twin entry turbine[J]. Energy Conversion & Management, 2012, 57: 68-78.
[14] Wang J, Shen L, Bi Y, et al. Power recovery of a variable nozzle turbocharged diesel engine at high altitude by response surface methodology and sequential quadratic programming[J]. Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering, 2018, 233(4): 810-823.
[15] 林春城, 劉瑞林, 董素榮, 等. 柴油機高原可調增壓技術[J]. 軍事交通學院學報, 2015(9): 41-46. Lin Chuncheng, Liu Ruilin, Dong Surong, et al. Adjustable supercharging technology for diesel engine at plateau[J]. Journal of Academy of Military Transportation, 2015(9): 41-46. (in Chinese with English abstract)
[16] 李書奇, 鄧春龍, 陳剛, 等. 放氣閥增壓器在柴油機高原環境適應性改進中的應用研究[J]. 車用發動機,2016(3):52-57. Li Shuqi, Deng Chunlong, Chen Gang, et al. Application of waste-gate turbocharger in plateau environment adaptability improvement of diesel engine[J]. Vehicle Engine, 2016(3): 52-57. (in Chinese with English abstract)
[17] 靳嶸, 張俊躍, 胡力峰, 等. 高原自適應柴油機渦輪增壓技術研究[J]. 內燃機工程, 2011, 32(4): 27-31. Jin Rong, Zhang Junyue, Hu Lifeng, et al. Study on varying altitude self-adaptive turbocharging system for diesel engine[J]. Chinese Internal Combustion Engine Engineering, 2011, 32(4): 27-31. (in Chinese with English abstract)
[18] Carlucci A P, Ficarella A, Trullo G. Performance optimization of a two-stroke supercharged diesel engine for aircraft propulsion[J]. Energy Conversion and Management, 2016, 122: 279-289.
[19] 李華雷, 石磊, 鄧康耀, 等. 兩級可調增壓系統變海拔適應性研究[J]. 內燃機工程, 2015, 36(3): 1-5. Li Hualei, Shi Lei, Deng Kangyao, et al. Calculation research on variable altitude adaptability of regulated two-stage turbocharging system[J]. Chinese Internal Combustion Engine Engineering, 2015, 36(3): 1-5. (in Chinese with English abstract)
[20] 謝海江, 李華雷, 邢衛東. 基于變海拔功率恢復的增壓系統匹配計算研究[J]. 車用發動機, 2017(3):82-87. Xie Haijiang, Li Hualei, Xing Weidong. Matching calculation of turbocharging system based on power recovery at different altitudes[J]. Vehicle Engine, 2017 (3):82-87. (in Chinese with English abstract)
[21] 韓愷, 朱振夏, 張付軍, 等. 可調復合增壓柴油機高原功率恢復方案研究[J]. 兵工學報, 2013, 34(2): 129-136. Han Kai, Zhu Zhenxia, Zhang Fujun, et al. Research on composite adjustable supercharged program of diesel engine for power recovery[J]. Acta Armamentarii at Plateau, 2013, 34(2): 129-136. (in Chinese with English abstract)
[22] Xia M. Research of turbo-supercharging system based on power recovery of diesel engine at plateau[C]// SAE 2016 Commercial Vehicle Engineering Congress, 2016.
[23] 商海昆, 董長龍, 李萍, 等. 高原用柴油機雙增壓器匹配研究[J]. 內燃機工程, 2017, 38(4): 115-120. Shang Haikun, Dong Changlong, Li Ping, et al. Research on the matching of double-turbocharger of diesel engine in the plateau[J]. Chinese Internal Combustion Engine Engineering, 2017, 38(4): 115-120. (in Chinese with English abstract)
[24] 趙偉, 葛蘊珊, 陸紅雨, 等. 電控共軌柴油機海拔特性仿真[J]. 汽車工程, 2014, 36(1): 32-37. Zhao Wei, Ge Yunshan, Lu Hongyu, et al. A simulation on the altitude characteristics of electronically-controlled common rail diesel engine[J]. Automotive Engineering, 2014, 36(1): 32-37. (in Chinese with English abstract)
[25] 劉殿元. 略論青藏高原地區人體的生理特點及適應性[J]. 青海師范學院學報: 自然科學版, 1980 (1): 54-60.
[26] Capobianco M, Marelli S. Waste-gate turbocharging control in automotive SI engines: effect on steady and unsteady turbine performance[C]//Asia Pacific Automotive Engineering Conference, 2007.
[27] Capobianco M, Marelli S. Experimental analysis of unsteady flow performance in an automotive turbocharger turbine fitted with a waste-gate valve[J]. Proceedings of the Institution of Mechanical Engineers Part D Journal of Automobile Engineering, 2011, 225(8): 1087-1097.
[28] 黃粉蓮, 紀威, 周煒. 渦輪增壓柴油機進氣流量的計算與仿真[J]. 農業工程學報, 2013, 29(3): 62-68. Huang Fenlian, Ji Wei, Zhou Wei . Calculation and simulation of air mass flow for turbocharged diesel engines[J]. Transactions of the Chinese Society of Agricultural Engineering (Transa-ctions of the CSAE), 2013, 29(3): 62-68. (in Chinese with English abstract)
[29] 劉瑞林, 劉宏威, 秦德. 渦輪增壓柴油機高海拔(低氣壓)性能試驗研究[J]. 內燃機學報, 2003, 21(3): 213-216. Liu Ruilin, Liu Hongwei, Qin De. An experimental study on performance of turbocharged diesel engines at high altitude (low air pressure)[J]. Transactions of CSICE, 2003, 21(3): 213-216. (in Chinese with English abstract)
[30] 劉瑞林, 周廣猛, 李駿, 等. 高壓共軌柴油機高海拔全負荷標定[J]. 燃燒科學與技術, 2012, 18(3): 199-205. Liu Ruilin, Zhou Guangmeng, Li Jun, et al. Calibration of common-rail diesel engine at high altitudes under full load operating conditions[J]. Journal of Combustion Science and Technology, 2012, 18(3): 199-205. (in Chinese with English abstract)
[31] 劉系暠, 魏名山, 馬朝臣, 等. 不同海拔下單級和二級增壓柴油機的仿真[J]. 內燃機學報, 2010, 28(5): 447-452. Liu Xihao, Wei Mingshan, Ma Chaochen, et al. Simulation on one-stage and two-stage turbocharged diesel engines at different altitudes[J]. Transactions of CSICE, 2010, 28(5): 447-452. (in Chinese with English abstract)
[32] 劉瑩, 葛煒, 張繼忠, 等. 兼顧平原與高原性能的二級增壓系統性能試驗研究[J]. 內燃機工程, 2017, 38(2): 123-127. Liu Ying, Ge Wei, Zhang Jizhong, et al. Experimental research on performance of two-stage turbocharging system at both plain and plateau[J]. Chinese Internal Combustion Engine Engineering, 2017, 38(2): 123-127. (in Chinese with English abstract)
Turbocharger matching in plateau area and adaptability of small agricultural diesel engine
Wang Jun1, Shen Lizhong2, Wen Yijun3, Xue Shuang3, Zhao Jie3
(1.,,650224,; 2.,,650500,; 3..,.,650200,)
The environment pressure and air density experience sharp declines at high altitude, which cause a large drop in the intake air mass flow rate of diesel engines. As a result, many aspects of engine performance are deteriorated, such as power, fuel consumption and emissions. Turbocharging matching provides a good technical solution for recovery diesel engine performance at high altitude. There is a large number of agricultural machinery operating in plateau area of China. In order to ensure that the agricultural machinery used in these areas had a good plateau adaptability, taking a small agricultural diesel engine as the research object, an appropriate compressor and turbine were selected respectively through theoretical calculation according to the design and development goals at altitude of 2 000 m. After that, the matching test of the small agricultural diesel engine and selected turbocharger was conducted at this altitude. Finally, the simulation model of the small agricultural turbocharged diesel engine was built by using GT-Power code based on test data. The change rule of diesel engine key performance parameters were simulated and investigated at altitudes of 0, 2 000 and 4 000 m. The results showed that the selected turbocharger made the small agricultural diesel engine achieve the development requirements at the altitude of 2 000 m. Low-end torque reached 120.1 N·m at 1 000 r/min, the peak torque was 180.2 N·m at 1 600 r/min, the rated power was 37.4 kW at 2 600 r/min, and the torque backup coefficient was 131% at this altitude. At 3 altitudes of 0, 2 000 and 4 000 m, the joint operation lines of the small agricultural diesel engine and the selected compressor were all operating in the relatively high efficiency area, and there were a large surge margin at low engine speeds, and also a certain distance from the choke line at high engine speeds. As the altitude went up, the engine torque and boost pressure decreased, while brake specific fuel consumption and turbine inlet gas temperature increased. What’s more, with respect to high engine speed, the change of altitude had a greater impact on engine power and economy performance at low engine speed. With the increase of altitude, decreasing amplitude of torque and percentage gain of fuel consumption was both rose at low engine speed, and these tendency were decline gradually with the increase of engine speed. In addition, the engine speed corresponding to the peak torque showed a tendency of gradually moving towards higher engine speed at high altitude. Compared with plain area, the maximum engine torque decreased by 2.59% and 7.19% respectively when it ran at altitudes of 2 000 and 4 000 m. Meanwhile, compared with the previous literatures conclusion, the decreasing amplitude of peak engine torque was smaller when the small agricultural diesel engine operating at altitudes of 2 000 and 4 000 m, respectively. It can ensure the good operation performance of diesel engine in plateau area, and also is beneficial to improve the plateau adaptability when diesel engine and turbocharger are matched at high altitude.
diesel engine; plateau; turbocharger matching; different altitude; adaptability
2019-04-23
2019-07-30
云南省農業聯合青年項目(2018FG001-096);云南省教育廳科學研究基金項目(2018JS337);西南林業大學校級科研專項項目(111912)
王 俊,博士,講師,主要從事內燃機增壓技術研究。Email:zjwj1121@163.com
10.11975/j.issn.1002-6819.2019.16.008
TK421.8
A
1002-6819(2019)-16-0070-08
王 俊,申立中,文奕鈞,薛 爽,趙 杰.小型農用柴油機高原增壓匹配與適應性研究[J]. 農業工程學報,2019,35(16):70-77. doi:10.11975/j.issn.1002-6819.2019.16.008 http://www.tcsae.org
Wang Jun, Shen Lizhong, Wen Yijun, Xue Shuang, Zhao Jie. Turbocharger matching in plateau area and adaptability of small agricultural diesel engine[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2019, 35(16): 70-77. (in Chinese with English abstract) doi:10.11975/j.issn.1002-6819.2019.16.008 http://www.tcsae.org